"Gazelle" Gas-2705>> Car maintenance service>> Car greasing
In the course of carrying out of maintenance service of the car use of other marks горючезмазочных materials and liquids, except specified in tab. 11.4, 11.5 and 11.6 is forbidden.
Before making greasing, remove a dirt from press butterdishes and stoppers to avoid its penetration into car mechanisms.
To make greasing a syringe follows until fresh greasing will not seem from places of joints of details of the knot which is exposed to greasing.
At replacement of engine oil by oil of other mark or other firm washing of system of greasing промывочным oil is obligatory.
Mixing (доливка) engine oils of various marks and various firms is forbidden.
Table 11.4. A greasing card
|
The name of a point of greasing
|
Кол. Points
|
Кол. смазоч. A material
|
The name of greasing, oil
|
Periodicity
|
Performed works
|
|
|
|
|
|
ТО-1
|
ТО-2
|
WITH
|
|
|
System of greasing of the engine
|
1
|
6 l
|
Tab. 11 see. 5
|
+
|
+
|
-
|
To replace oil and filtering element of the oil filter (section 4.1 see) - ЗМЗ-4025, 4026. To replace oil and the oil filter - engines 4215, ЗМЗ-4061, 4063.
|
|
The plug of a rotor of the gauge-distributor of ignition (421 ЗМЗ-4025, 4026)
|
1
|
|
Oil for the engine
|
-
|
+
|
-
|
To grease with 4-5 drops the rotor plug
|
|
Carter of a transmission
|
1
|
1,2 l
|
At temperature from-25 ° With to +40 ° About oil «Super Т-3". Duplicating oils: ТСп-15К, «Ufaljub an unitrance», «Devon SuperT». At temperature from-40 ° With to +20 ° About oil "Lukoil TM-5" SAE 75W90
|
-
-
|
+
+++
|
-
-
|
To check up level and, if necessary to add to level of the bottom edge of a jellied aperture (for a stopper located on the right side) or on 7 mm below level of the bottom edge of a jellied aperture (for a stopper located on the left side). To replace oil, to clear a magnetic drain stopper.
|
|
Needle bearings карданных hinges
|
3
|
60 г
|
Oil «Super Т-3». Duplicating oils: "Ufaljub Unitras", «Devon Super Т»
|
-
|
+
|
-
|
To replace through press butterdishes to an exit of fresh greasing from under all consolidations
|
|
Plugs and basic bearings шкворней rotary fists
|
2
|
25 г
|
Солидол With
Duplicating greasing of Solidol
|
+
|
+
|
-
|
To grease through a press butterdish before occurrence of greasing from under a sealant of the basic bearing and from a backlash between the top lug of a fist and a beam. In case of an exit of greasing from under a cover шкворня it is necessary to tighten bolts of fastening of a cover and to wash out шкворневое connection by a mix трансмиссионного oils with kerosene in the ratio 1:1 through a press butterdish
|
|
Carter of the back bridge
|
1
|
3,0 l (2,2*)
|
At temperature from-25 ° With to +40 ° About oil «Super Т-3". Duplicating oils: «Ufaljub an unitrance», «Devon SuperT». At temperature from-40 ° With to +20 ° About oil "Lukoil TM5" SAE 75W90
|
-
-
|
+
+++
|
-
-
|
To check up level and, if necessary, to add to level of a control stopper. To replace oil, to clear a magnetic drain stopper after operation at low temperatures on oil with addition of diesel fuel, to replace oil in the spring
|
|
Bearings of naves of back wheels
|
4
|
66 г
|
At temperature from-25 ° With to +40 ° About oil «Super Т-3". Duplicating oils: «Ufaljub an unitrance», «Devon SuperT». At temperature from-40 ° With to +20 ° About oil "Lukoil TM5" SAE 75W90
|
-
|
+++
|
-
|
At oil change in the back bridge to remove naves, to wash out their kerosene, to dry, put on 15 г greasings in each bearing and in a cavity between working edges of cuffs on 2/3 volumes. To grease working edges of a cuff with a thin layer of greasing.
|
|
Bearings of naves of forward wheels
|
4
|
270 г
|
Литол-24. Duplicating greasing of LIT
|
-
|
+++
|
-
|
To remove naves, to wash out kerosene, to dry to put fresh greasing on 15 г in internal bearings, on 10 г in external bearings, on 110 г in a cavity of naves and in a cavity between working edges of cuffs, having greased edges with a thin layer of greasing. To establish naves and to make adjustment of bearings
|
|
Shock-absorbers
|
4
|
0,28х4=112 г
|
АЖ-12Т. A duplicating liquid - веретенное oil АУ
|
-
|
-
|
-
|
To replace, at necessity, a liquid
|
|
Carter of the steering mechanism
|
1
|
0,45-0,5 l
|
Oil «Super Т-3» Duplicating oils: «Ufaljub the Unitrance», «Devon Super Т»
|
-
|
+
|
-
|
To check up level and, if necessary, to add. Oil level should be within 15 mm downwards from the bottom edge of a jellied aperture
|
|
Sealant of a steering shaft
|
1
|
5 г
|
Greasing Litol-24. Duplicating greasing of LIT
|
-
|
-
|
+
|
To shift an edge of a sealant and to grease a working surface of a shaft
|
|
Kardannye hinges of a steering drive
|
4
|
7 г
|
Литол-24. Duplicating greasings: Солидол With, Solidol
|
-
|
-
|
+
|
To grease through a press butterdish before occurrence of fresh greasing
|
|
Popolnitelnyj tank of the main brake cylinder
|
1
|
0,52 l
|
Brake liquid «РОСДОТ». A duplicating liquid "Tom'"
|
-
|
-
|
+
|
To replace a liquid two times a year (spring)
|
|
Tank of the main cylinder of a hydrodrive of deenergizing of coupling
|
1
|
0,2 l
|
Brake liquid «РОСДОТ». A duplicating liquid "Tom'"
|
-
|
-
|
+
|
To replace a liquid two times a year (spring)
|
|
Plugs of the storage battery
|
2
|
10 г
|
Plastic greasing ПВК or солидол
|
-
|
-
|
+
|
To grease with a thin layer
|
|
Locks and drives of locks of doors (external and internal)
|
28
|
40 г
|
Oil ВМГЗ or МГЕ10А
|
-
|
+
|
+
|
|
|
Switches of locks of doors
|
4
|
8 г
|
Литол-24. Duplicating greasing of LIT
|
-
|
-
|
+
|
Before greasing to wash out
|
|
Terminators of doors of a cabin
|
2
|
2 г
|
Литол-24. Duplicating greasing of LIT
|
-
|
-
|
+
|
To grease the lever as required at scratch occurrence
|
|
Rubbing surfaces directing to a lateral door
|
3
|
30 г
|
Литол-24. Duplicating greasing of LIT
|
-
|
+
|
-
|
Before greasing to wipe
|
|
The cowl lock
|
1
|
1 г
|
Oil ВМГЗ or МГЕ10А
|
|
|
|
At necessity, at latch jamming
|
|
Drive of the lock of a cowl
|
1
|
15 г
|
Литол-24. Duplicating greasing of LIT
|
-
|
-
|
+
|
Before greasing to wash out. To grease rubbing surfaces with a thin layer
|
|
Cowl loops
|
2
|
2 г
|
Oil ВМГЗ or МГЕ10А
|
-
|
-
|
+
|
To grease at necessity, at scratch occurrence
|
|
The bearing of the top roller of a lateral door of motor vans and buses
|
1
|
20 г
|
Литол-24, LITS or ЦИАТИМ-201
|
+
|
+
|
-
|
To put greasing
|
|
System of cooling of the engine
|
1
|
9,7 ** l
11,5 *** l
|
Cooling liquids ТОСОЛ-А40М, ОЖ-40, "Lena", "Termosol", Mark А-40
|
-
|
-
|
+
|
To check up density at seasonal service
|
* For the one-piece bridge with запрессованными casings.
** For cars with one heater.
*** For cars with an additional heater (buses and motor vans with two rows of seats).
Table 11.5. The list of the certificated engine oils
|
Engine model
|
Number marks
|
Viscosity classes on SAE
|
Classification by HUNDRED ААИ 003-98 (API)
|
GOST, THAT
|
Application
|
|
Семейтсво engines ZMZ-402 and 4215
|
«Motor Ojl multinational corporation»
|
5W-30, 10W-30, 10W-40, 15W-40
|
БЗ/Д1 (SF/СС)
|
ТУ-38.301-41-148-01
|
5W-30 from-25 to +20°С
5W-40 from-25 to +35°С
10W-30 from-20 to +30°С
10W-40 from-20 to +35°С
15W-40 from-15 to +35°С
15W-40 from-15 to +45°С
20W-40 from-10 to +45°С
SAE30 From-5 to +45 ° With
|
|
|
Уфалюб
|
15W-40
|
БЗ/Д1 (SF/СС)
|
THAT 38.302.032-90
|
|
|
|
Ufaljub-lux
|
10W-30, 15W-40
|
БЗ/Д1 (SF/СС)
|
THAT 0253.004.05766540-96
|
|
|
|
Антрол
|
10W-30
|
БЗ/Д1 (SF/СС)
|
THAT 38.601.01.220-92
|
|
|
|
Норси
|
10W-30, 10W-40 15W-40, 20W-40
|
БЗ/Д1 (SF/СС)
|
THAT 38.601.07.21-94
|
|
|
|
"Jar-mark" 1 and 2
|
10W-30, 15W-40
|
БЗ/Д1 (SF/СС)
|
THAT 38.301.25.19-95
|
|
|
|
Нафтан MB
|
15W-40
|
БЗ/Д1 (SF/СС)
|
THAT РБ 057784770-90-96
|
|
|
|
Самойл
|
10W-30, 10W-40, 15W-30, 15W-40, 20W-40
|
БЗ/Д1 (SF/СС)
|
THAT 38.301.12002-94
|
|
|
|
Велс 1 and 2
|
10W-30
|
БЗ/Д1 (SF/СС)
|
THAT 0253.072.00148636-95
|
|
|
|
«The standard 3,5»
|
10W-30, 15W-40
|
БЗ/Д1 (SF/СС)
|
THAT 38.301.-19-79-98
|
|
|
|
«Lukoil the Standard»
|
10W-30, 15W-40
|
БЗ/Д1 (SF/СС)
|
THAT 38.301-29-93-95
|
|
|
|
Спектрол
|
10W-30, 10W-40, 15W-30
|
БЗ/Д1 (SF/СС)
|
THAT 0253.003.069113380-95
|
|
|
|
Jar-mark »Ekstra
|
5W-30, 5W-40
|
БЗ/Д2 (SF/СD)
|
THAT 38.301.25.36-97
|
|
|
|
Ферганол
|
30
|
БЗ (SF)
|
THAT Ouse. 39.3-145-96
|
|
|
|
«A3 THE PIER»
|
15W-40, 20W-40
|
БЗ/Д1 (SF/СС)
|
THAT AT 00152365060-97
|
|
|
|
"Yukos-plus"
|
5W-30, 10W-30, 10W-40, 15W-40, 20W-40
|
БЗ/Д1 (SF/CC)
|
THAT 0253-003-48120848-98
|
|
|
|
ESSO Extra
|
10W-30, 15W-40
|
БЗ/Д1 (SF/CC)
|
The specification ф. ESSO
|
|
|
Family of engines ZMZ-406
|
«Lukoil Super»
|
5W-30, 5W-40
|
Б4/Д2 (SG/CD)
|
THAT 0253-078-00148636-96
|
5W-30 from-25 to +20 ° With
5W-40 from-25 to +35 ° With
10W-30 from-20 to +30°С
10W-40 from-20 to +35°С
15W-40 from-15 to +45°С
20W-40 from-10 to +45°С
|
|
|
«Jar-mark Super»
|
5W-30, 5W-40
|
Б4/Д2 (SG/CD)
|
THAT 38.301.25.37-97
|
|
|
|
Novojl-Sint
|
5W-30, 5W-40
|
Б4/Д2 (SG/CD)
|
THAT 0253-004-05766528-97
|
|
|
|
ESSO ULTRA
|
10W-40
|
SJ/SH/CF
|
The specification ф. ESSO
|
|
|
|
ESSO UNIFLO
|
15W-40
|
SJ/SH/CF
|
The specification ф. ESSO
|
|
|
|
«Omskojl Lux»
|
5W-30, 5W-40, 10W-30, 10W-40, 15W-40, 20W-40
|
Б4/Д2 (SG/CD)
|
THAT 308.301.19-113-98
|
|
|
|
«Yukos Super»
|
5W-40, 10W-40, 15W-40
|
Б4/Д2 (SG/CD)
|
THAT 0253-011-48120848-98
|
|
|
|
«Lukoil Super»
|
5W-40, 10W-40, 15W-40
|
Б4/Д2 (SG/CD)
|
THAT 0253-075-00148636-99
|
|
|
|
«Lukoil Lux»
|
5W-40, 10W-40, 15W-40
|
Б4/Д2 (SG/CF)
|
THAT 0253-088-00148636-97
|
|
|
|
«Lukoil Super»
|
5W-30, 5W-40, 10W-30, 10W-40, 15W-40
|
Б4/Д2 (SG/CD)
|
THAT 308.601-07-46-02
|
|
|
|
"Multinational corporation-super-Ojl"
|
5W-40, 10W-40, 15W-40, 20W-40
|
Б4/Д2 (SG/CD)
|
THAT 308.301-41-171-01
|
|
|
|
«Havoline F3X1 Extra»
|
10W-40
|
Б4/Д2 (SJ/CF)
|
The specification ф. Тексако
|
|
|
|
«Havoline F3»
|
10W-40, 15W-40
|
Б4/Д2 (SJ/CF)
|
The specification ф. Тексако
|
|
|
|
"Jar Mark Ljuks"
|
5W-30, 5W-40, 10W-30, 15W-40
|
Б4/Д2 (SJ/CF)
|
THAT 0253-010-17915330-99
|
|
|
|
«Люкс-1», 2, 3, 4, 5, 6
|
5W-30, 5W-40, 10W-30, 10W-40, 15W-40, 20W-40
|
Б4/Д2 (SG/CD)
|
THAT 308.301-19-113-98
|
|
Table 11.6. Foreign analogues of combustive-lubricating materials and operational liquids
|
Materials of the Russian manufacture
|
Classification, the specification, analogues
|
The note
|
|
Gasoline АИ-93
|
Регуляр 91-96 RON
|
(RON - octava number on a research method)
|
|
Engine oils
|
SAE 5 w/30; SAE 15 w/30; SAE 20 w/30; Oils of firm "ESSO" API of SJ/SH/CD of marks ULTRON, ULTRA, UNIFLO
|
|
|
Transmissionnye oils
|
API GL-5; SAE 85 W90
|
|
|
Greasing Litol-24
|
Mil-G-18709A; Mil-G-10924C
|
The specified analogues are applied in transmission knots, except a back place
|
|
LIT greasing
|
SM-iC-4515A (Ford)
|
|
|
Солидол With or
|
VWTL-738; Mil-G-10924C; SM1C-74 A (Ford)
|
|
|
Graphitic greasing УСсА
|
W-G-671 d 078.01 (RFA)
|
|
|
Cooling liquid ТОСОЛ-А40М or ОЖ "Lena"
|
Antifreeze on a basis этиленгликоля with a complex ингибиторов corrosion and пеногасителем
|
|
|
Brake liquid «РОСДОТ», "Tom'"
|
Brake liquids of type DOT-4 or DOT-3, SAE I 1703f FMVSS 116A
|
To apply according to the recommendation of the dealer who has sold the car
|
|
|